-
Instructions on How to Measure Turbocharger Wheels
Aug , 08 2022
Wheel diameter measurement is essential when replacing or upgrading a turbocharger.However, measuring wheel diameter is not as simple as pulling out a tape measure or caliper. You need to measure data at different points, such as inducers (incoming), exducer (outgoing). At the same time, you should also pay attention to the measurement method of the different number of blades. The measurement tool...
Read More
-
The differences between diesel and petrol engines
Aug , 22 2022
The common Turbo on the market is generally used in Diesel and Petrol engines,but do you know the differences between Diesel and Petrol engine? And how Turbo affect the Diesel and Petrol engines? Diesel First of all, diesel isn’t as much combustible as petrol, which means that the air/fuel mix in the combustion chamber of diesel engines needs to be at a higher pressure to ignite. These higher pres...
Read More
-
Turbocharger maintenance points
Dec , 29 2022
Carefully warm up the car. After the engine starts, do not rush the accelerator pedal, should first idle for a minute or two. Make the turbocharger get fully lubricated, then you can increase the engine speed and start driving. Especially in winter, idle warm-up time should be lengthened to 3 to 5 minutes, at the same time can not blast the accelerator to accelerate the warm-up, to prevent da...
Read More
-
What will happen when the cylinder pressure is not enough?
Mar , 07 2023
The phenomenon of insufficient cylinder pressure. Excessive carbon accumulation and severe engine shaking. Affects the combustion efficiency, power decreases, fuel consumption is too high, and even high temperature. If it is caused by piston seal, it will also cause serious carbon accumulation in the combustion chamber and poor emission. And engine life is seriously shortened. Combustible mixture ...
Read More
-
Symptoms of insufficient cylinder pressure during driving
Mar , 07 2023
If the cylinder pressure is not enough, there will be a lack of power and a lot of smoke from the exhaust pipe while driving. If the cylinder pressure is not enough, the engine will be difficult to start. Insufficient cylinder pressure is generally caused by an air leak in a part of the engine, or it may be caused by a large gap between the piston and the cylinder wall。 If the piston and the cylin...
Read More
-
Does a turbocharger last only 10 years?
Apr , 10 2023
1、Good engine oil is important Because of the high temperature of turbocharger in the process of use and its special structure, there are special requirements in the selection of engine oil. The oil used in the maintenance of ordinary gasoline engine models can not meet the requirements of turbocharged models. Therefore, in the maintenance process must use the special oil for turbocharged vehicles...
Read More